Product ID:BATTERY ELECTRIC STORAGE,WET,PC-31-625 C
MSDS Date:04/15/1986
FSC:6140
NIIN:01-134-5413
MSDS Number: BHJGP

GNB INC INDUSTRIAL BATTERY DIV WOODLAKE CORP PARK

829 PARKVIEW BOULEVARD
LOMBARD, IL 60148-3249
US

Emergency Phone: 708-691-7886/800-424-9300(CHEMTREC)

Info Phone: 708-691-7886

Cage: 88219

GNB INC.

SAINT PAUL (MENDOTA HTS), MN 55118 US

Telephone: 612-681-5000

Cage: 0MM77

LEAD (SARA III)

CAS: 7439-92-1

RTECS: OF7525000

Fraction By Weight: 50%

OSHA PEL 0.05 MG/M3;1910.1025

ACGIH TLV: 0.15 MG/M3;DUST 9293

EPA Report Quantity: 1 LB

DOT Report Quantity: 1 LB

SULFURIC ACID (SARA III)/ELECTROLYTE

CAS: 7664-93-9

RTECS: WS5600000

Fraction By Weight: 27%

OSHA PEL 1 MG/M3

ACGIH TLV: 1 MG/M3; 9293

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

Routes of Entry: Inhalation:NO Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE AND CHRONIC- THIS IS A
NON-SPILLABLE BATTERY. IF THE BATTERY IS BROKEN, LEADING OR ON
FIRE, CAN CAUSE EYE, SKIN IRRITATION AND BURNS. CHRONIC- NONE
KNOWN.
Effects of Overexposure:STINGING AND BURNING SENSATION TO SKIN AND
EYES.
Medical Cond Aggravated by Exposure:NONE KNOWN

First Aid:GET MEDICAL ATTENTION IMMEDIATELY. EYE/SKIN:IMMEDIATELY FLUSH
WITH WATER FOR AT LEAST 15 MINUTES. HOLD EYELIDS OPEN.
INHALED:REMOVE TO FRESH AIR. ORAL:NOT LIKELY.

Extinguishing Media:DRY CHEMICAL
Fire Fighting Procedures:ORDINARY
Unusual Fire/Explosion Hazard:WHEN ON CHARGE AND APPROACHING FULL
CHARGE, GASES GENERATED ARE VOLATILE (OXYGEN AND HYDROGEN). KEEP
AWAY SOURCES OF IGNITION (SPARKS & FLAMES).

Spill Release Procedures:WEAR ACID-RESISTANT CLOTHING, BOOTS, GLOVES
AND FACE SHIELD. VENTILATE AREA. STOP FLOW OF MATERIAL.
CONTAIN/ABSORB SPILLS WITH DRY SAND, EARTH, VERMICULITE. CAREFULLY
NEUTRALIZE WITH SODA ASH, SODIUM BICARBONATE, LIME. DO NOT
DISCHARGE TO SEWER.
Neutralizing Agent:SODA ASH, BAKING SODA

Handling and Storage Precautions:STORAGE- STORE WITH VENT-SIDE UP. BE
CERTAIN VENTS ARE FREE OF DIRT TO INSURE AIR FLOW.
Other Precautions:DO NOT SHORT OUT POSITIVE AND NEGATIVE ELECTRODES
WITH A CONDUCTOR. THIS MAY CAUSE A HOT ELECTRICAL SPARK.

Respiratory Protection:NONE NORMALLY REQUIRED.
Ventilation:ADEQUATE
Protective Gloves:RUBBER
Eye Protection:SAFETY GOGGLES OR FACE SHIELD (CHARGING)
Other Protective Equipment:RUBBER APRON WHEN CHARGING
Work Hygienic Practices:AVOID SOURCES OF IGNITION WHEN CHARGING.
Supplemental Safety and Health

HCC:N1
Appearance and Odor:BATTERY

Stability Indicator/Materials to Avoid:YES
Stability Condition to Avoid:SPARKS AND FLAMES WHILE ON CHARGE.

Waste Disposal Methods:DO NOT DISPOSE OF BATTERY. SPENT OR UNUSABLE
BATTERIES SHOULD BE RECYCLED BY A LICENSED BATTERY RECYCLER.
OBSERVE ALL LOCAL, STATE AND FEDERAL REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.